Show Posts

This section allows you to view all posts made by this member. Note that you can only see posts made in areas you currently have access to.


Topics - Seabeowner

Pages: [1] 2 3
1
CB500/550 / Candy Garnet Brown
« on: February 26, 2024, 05:07:19 PM »
Looking for criticism and sources for paint.
I have an old tank that I have de-rusted and filled a few small dents. It is not really worth spending money on a professional finish as it will be another spare. I have sprayed a few bikes, but that was 40 years ago! And fifty years ago I bought a new 500 (my avatar) in candy garnet brown, so that is the colour for this one.

1.   Spray with etch primer because that’s what our factory sprayer did first when I was working. Do I need this?
2.   Spray with epoxy primer. Final light rub down.
3.   Base coat. What do I need?
4.   Spray candy garnet brown all over. How much paint do I need. 500ml seems enough.
5.   Cure.
6.   Mask for black panels at side of tank.
7.   Spray black.
8.   Cure.
9.   Apply striping decals.
10.   Spray 2K lacquer. I know it’s nasty stuff.

Intend to use aerosol rattle cans for steps 1, 2, and 10.
Will also do a test piece as I progress to check paint compatibility.
This has been on here before, but looking for sources and recommendations for paint. I only remember RS paint.
Thanks for any info/advice.

2
Misc / Open / Classic bike oversupply
« on: January 30, 2024, 10:16:37 AM »

3
CB500/550 / UK CB500 for sale.
« on: December 28, 2023, 06:47:55 PM »

4
Member 4 Sales / CB500 CB750 Lights on/off Switch
« on: February 17, 2023, 09:49:36 AM »
On/off switch fits on left side of bars on UK CB500 and some CB750s. 35150-300-730
Packet opened, but new condition.
Very expensive for what they are. Am asking £46 inc UK post, as they are £58.50 from DSS.

5
CB500/550 / Are these a Bargain?
« on: January 13, 2023, 08:56:10 AM »

6
CB500/550 / Another early square 500
« on: April 21, 2022, 05:47:02 PM »
Low miles. Looks original front tyre. (although axle clamp incorrectly fitted)

https://www.ebay.co.uk/itm/284777116544?hash=item424e09f380:g:z20AAOSwn9tiYFHu

When I started getting back into SOHCs in 2003, bikes were rare. Now there seem very common.

8
CB500/550 / 550F with Spare silencer
« on: January 22, 2022, 07:10:49 PM »
https://www.carandclassic.com/car/C1418348

Steve: Maybe we should have a separate section for offers/bikes deals that we spot.

9
Misc / Open / Speedo and Tacho dashpot?
« on: September 24, 2021, 10:46:33 AM »
Can someone explain how the dashpot on the tach and speedo meter works?
Have a tach apart. The needle is driven up by a fight between the magnetic coupling at the bottom and the coiled spring on the shaft. That bit seems simple. Above the spring is the dashpot. What goes on in there? The dashpot itself seems fixed to the shaft as does the needle above it. So it all moves together.
Plus tips for refilling with silicone oil.

10
CB500/550 / CB500 Fork Damping
« on: May 20, 2021, 11:28:21 PM »
Have the forks off my 73K1 as they seem to rattle and crash about over speed humps and the like. Found one spring is about 4mm longer than the other and one of the dampers feels uneven when I pull the rod up/down. I also have a spare fork set, so will mix and match the best bits.
The damper is a one piece assy with the long rod that attaches to the top cap. K0, K1s and some CB450s. Presume the damper wears, is there any way to service?
Also this is listed by wemoto for K0 but presume it is not suitable.
https://www.wemoto.com/bikes/honda/cb_500_four_k0/71/picture/fork_valves

12
CB500/550 / Exhausts...End of the line.
« on: June 14, 2019, 04:03:22 PM »
I notice that DSS and CMSNL are no longer listing the 4/4 aftermarket exhaust sets.
Could get a set here!!!!

https://www.ebay.co.uk/itm/Honda-CB500-CB-500-CB550-CB-550-NOS-HM323-complete-exhaust-set/223549533225?hash=item340c972c29:g:I~wAAOSwdxddARkC

13
CB500/550 / Replacement Sleeving for Wiring Loom
« on: June 14, 2019, 03:51:06 PM »
I need to replace the sleeving for the main harness that goes from under the tank to the headlight bucket. It's about 18mm diameter I think.
Anyone have a recommended supplier? I only need a couple of feet.

14
CB500/550 / Clutch Cable.
« on: March 03, 2019, 07:17:53 PM »
Anyone have experience with the clutch cable sold by DSS for 500. Says it is produced by OE manufacturer, but much cheaper than Honda brand.

15
Other Bikes / 20% 0ff M&P
« on: February 25, 2019, 07:01:25 PM »
Just to say there is 20% off (over £25 spend) on ebay (using code available on their site) at M&P until 28 Feb.

Pages: [1] 2 3
SimplePortal 2.3.5 © 2008-2012, SimplePortal